Rollaclub - User contributions [en]

Tech:Engine/K Series/Push Rods

2011-10-07T02:58:16Z

Towe001:

'''K Motor Pushrods'''

[[file:K_Motor_Pushrods.jpg]]

1K -

2K(import) -

3K(early) - 172mm

3K - 175/176mm

4K - 186mm

4K(with lugs) - 180mm

5K(solid lifter, D-Dish piston) - 180mm

5k(hydraulic lifter, D-dish piston) - 150mm (Part No. 13781-13100)

5k(hydraulic lifter, shallow dish piston - 156mm (Part No. 13781-13081)

7k -

'''And for those Datsun push rods'''

[[File:Datsun_Push_Rods.JPG]]

From top down

141.5 mm: A10 engine

152 mm: short-deck engines (A12, A12A, and 1980 A13)

~167 mm: tall-deck engines (A14, A15, and 1974 A13)

Custom pushrods can be made to length from VW pushrods and using the A-series cup. They sit the turned down cup shaft on a ledge in the alloy. Custom made to your length and cheap.

Extracted from [http://datsun1200.com/modules/newbb/viewtopic.php?topic_id=45722&forum=1&post_id=318349#forumpost318349 datsun1200.com - pushrods]

----

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#K_Series K Series]

Go to [http://www.rollaclub.com/faq/index.php?title=Tech:Engine/K_Series/Heads Heads]

Go to [http://www.rollaclub.com/faq/index.php?title=Tech:Engine/K_Series/Camshaft Camshaft]

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page Main Page]

[http://www.rollaclub.com/ Rollaclub]

Main Page Old

2011-10-07T00:52:53Z

Towe001: /* General Information */

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template1|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]
*[[Series:K/Model/AE70/71/85/86/|How to put a 4age into your ke70]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K Series/Push Rods|Push Rods]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K Series/Intake manifolds|Intake manifolds]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

*[[Tech:Engine/K Series/How to wire a 5k electronic distributor|How to wire a 5k electronic distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

KE30/55
* [[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==
===General tips and hints===

* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

* [[Rear Leaf Springs]]

* [[Stud Pattern]]

=== KE1x Suspension ===

* [[Replacing front strut inserts on your KE1x]]

* [[Lowering KE1x Front using KE2x parts]]

* [[Suspension:KE1x Suspension/Tie Rods|Tie Rods]]

* [[Suspension:KE1x Suspension/Front Spring Upper Seats|Front Spring Upper Seats]]

=== KE2x Suspension ===
=== KE3x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE5x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE7x Suspension ===
[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.pdf KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

Title=Tech:Engine/K Series/Push Rods

2011-10-07T00:50:49Z

Towe001: moved Title=Tech:Engine/K Series/Push Rods to Tech:Engine/K Series/Push Rods

#REDIRECT [[Tech:Engine/K Series/Push Rods]]

Tech:Engine/K Series/Push Rods

2011-10-07T00:50:49Z

Towe001: moved Title=Tech:Engine/K Series/Push Rods to Tech:Engine/K Series/Push Rods

Push Rods

2011-10-07T00:50:01Z

Towe001: moved Push Rods to Title=Tech:Engine/K Series/Push Rods

#REDIRECT [[Title=Tech:Engine/K Series/Push Rods]]

Tech:Engine/K Series/Push Rods

2011-10-07T00:50:01Z

Towe001: moved Push Rods to Title=Tech:Engine/K Series/Push Rods

Section=new

2011-10-07T00:46:48Z

Towe001: moved Section=new to Push Rods

#REDIRECT [[Push Rods]]

Tech:Engine/K Series/Push Rods

2011-10-07T00:46:48Z

Towe001: moved Section=new to Push Rods

Tech:Engine/K Series/Push Rods

2011-10-07T00:44:45Z

Towe001: Created page with ''''K Motor Pushrods''' file:K_Motor_Pushrods.jpg 1K - 2K(import) - 3K(early) - 172mm 3K - 175/176mm 4K - 186mm 4K(with lugs) - 180mm 5K(solid lifter, D-Dish piston) -…'

File:K Motor Pushrods.jpg

2011-10-07T00:37:15Z

Towe001:

File:Datsun Push Rods.JPG

2011-10-07T00:02:36Z

Towe001:

Tech:Engine/K Series/5K-C/5K Hydraulic To Solid Lifter Conversion

2011-10-05T11:17:52Z

Towe001: /* 5K Hydraulic To Solid Lifter Conversion */

== 5K Hydraulic To Solid Lifter Conversion ==

Worried that your 5K hydraulic lifters won't be any good at high RPM? Many people consider this to be the biggest letdown of the 5K-C engine - other's say that the lifters are fine to 8000+ RPM. It is pretty much up to you, but many people still advise doing this conversion. (Here we will discuss how to convert Hydraulic Lifters back to Solid Lifters in a 5K-C).

'''''Easiest Solution;'''''

Well, Luckily for you, We have some very kind people on rollaclub who decided to share some little-known information that the 5K-C actually did come from factory in one vehicle with factory solid lifters! This means that if you can find this part, You won't have to mess around - just '''"bolt it on"''' It was fitted to a Toyota KM36RV-JR Liteace Van with a Toyota Part Number of ''13751-61020-'' this part number cross references to a 3F Landcruiser, So if you can find a 3F Landcruiser engine you'll have one and a half sets.

This part is listed on the Toyota EPC (Electronic Parts Catalogue). Here is a screenshot of the EPC page for the 5K Solid Lifter :

[[Image:5ksolids.jpg]]

''Many thanks go to Chris and Tony Scott for their research and extensive knowledge that they contributed to finding this part number''

'''''Other Solutions;'''''

''Xany's KE55 5K Solid Lifters;''

Ok basically the way we did it was trial and error, As I cant remember the actual measurements of the 5K hydro lifter. Find yourself some calipers and if you have a spare 5K lifter out of the block, measure the length and diameter of the lifter. Once you have that you can bascically just cross reference the measurements with a chev lifter of the same. Most of the chev lifters we found were solids. Once you have found the lifter that matches you'll then need to try and find some pushrods to fit. As I used a 3K head the pushrods had to be changed from ball - ball ends to ball and cup. I'd heard somewhere that A12 Datsun pushrods are a one peice ball and cup pushrod. So I found some of them and they actually did fit nicely....The only other thing I changed was the rocker gear as the 5K item isnt adjustable because of the hydraulic lifters. I changed to the 4K rocker gear, just remember though that there is 2 different 4K rocker gears, one with long posts and one with short.

'''Note: This will not work with an original 5K shallow combustion chamber head. You have to be running a taller head from a flat top piston motor (ie. 3k bigport), otherwise the A12 pushrods will be too long.''' -Felix

''Another Solution;''

For the solid lifter conversion is the lifters from a small block chev, Holden 308 v8 and Holden 6 are all the same. Wolverine/crane cams part number : CRC99250-4 chev solid lifter.
(Edit by Towe001 - Info by Nerfbat, Kickn5k)

* Looking for articles by anyone who has done it the hard way...

edit by AE25 - due to this same question being asked all the time I'd put together a solid lifter conversion FAQ which may be useful here
http://www.club-k.co.nz/Forums/viewthread.php?tid=14957#pid105004

----

''Article by Grimwolge, TRD, TRD_KE70 & Xany''

----

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#5K_.281496cc.29 5K (1496cc)]

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page Main Page]

[http://www.rollaclub.com/ Rollaclub]

Tech:Engine/K Series/5K-C/5K Hydraulic To Solid Lifter Conversion

2011-10-05T11:17:17Z

Towe001: /* 5K Hydraulic To Solid Lifter Conversion */

== 5K Hydraulic To Solid Lifter Conversion ==

Worried that your 5K hydraulic lifters won't be any good at high RPM? Many people consider this to be the biggest letdown of the 5K-C engine - other's say that the lifters are fine to 8000+ RPM. It is pretty much up to you, but many people still advise doing this conversion. (Here we will discuss how to convert Hydraulic Lifters back to Solid Lifters in a 5K-C).

'''''Easiest Solution;'''''

Well, Luckily for you, We have some very kind people on rollaclub who decided to share some little-known information that the 5K-C actually did come from factory in one vehicle with factory solid lifters! This means that if you can find this part, You won't have to mess around - just '''"bolt it on"''' It was fitted to a Toyota KM36RV-JR Liteace Van with a Toyota Part Number of ''13751-61020-'' this part number cross references to a 3F Landcruiser, So if you can find a 3F Landcruiser engine you'll have one and a half sets.

This part is listed on the Toyota EPC (Electronic Parts Catalogue). Here is a screenshot of the EPC page for the 5K Solid Lifter :

[[Image:5ksolids.jpg]]

''Many thanks go to Chris and Tony Scott for their research and extensive knowledge that they contributed to finding this part number''

'''''Other Solutions;'''''

''Xany's KE55 5K Solid Lifters;''

Ok basically the way we did it was trial and error, As I cant remember the actual measurements of the 5K hydro lifter. Find yourself some calipers and if you have a spare 5K lifter out of the block, measure the length and diameter of the lifter. Once you have that you can bascically just cross reference the measurements with a chev lifter of the same. Most of the chev lifters we found were solids. Once you have found the lifter that matches you'll then need to try and find some pushrods to fit. As I used a 3K head the pushrods had to be changed from ball - ball ends to ball and cup. I'd heard somewhere that A12 Datsun pushrods are a one peice ball and cup pushrod. So I found some of them and they actually did fit nicely....The only other thing I changed was the rocker gear as the 5K item isnt adjustable because of the hydraulic lifters. I changed to the 4K rocker gear, just remember though that there is 2 different 4K rocker gears, one with long posts and one with short.

'''Note: This will not work with an original 5K shallow combustion chamber head. You have to be running a taller head from a flat top piston motor (ie. 3k bigport), otherwise the A12 pushrods will be too long.''' -Felix

''Another Solution;''
For the solid lifter conversion is the lifters from a small block chev, Holden 308 v8 and Holden 6 are all the same. Wolverine/crane cams part number : CRC99250-4 chev solid lifter.
(Edit by Towe001 - Info by Nerfbat, Kickn5k)

* Looking for articles by anyone who has done it the hard way...

edit by AE25 - due to this same question being asked all the time I'd put together a solid lifter conversion FAQ which may be useful here
http://www.club-k.co.nz/Forums/viewthread.php?tid=14957#pid105004

----

''Article by Grimwolge, TRD, TRD_KE70 & Xany''

----

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#5K_.281496cc.29 5K (1496cc)]

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page Main Page]

[http://www.rollaclub.com/ Rollaclub]

Main Page Old

2011-03-04T04:38:43Z

Towe001: /* General Information */

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template1|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K Series/Intake manifolds|Intake manifolds]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

*[[Tech:Engine/K Series/How to wire a 5k electronic distributor|How to wire a 5k electronic distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

KE30/55
* [[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==
===General tips and hints===

* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

* [[Rear Leaf Springs]]

* [[Stud Pattern]]

=== KE1x Suspension ===

* [[Replacing front strut inserts on your KE1x]]

* [[Lowering KE1x Front using KE2x parts]]

* [[Suspension:KE1x Suspension/Tie Rods|Tie Rods]]

* [[Suspension:KE1x Suspension/Front Spring Upper Seats|Front Spring Upper Seats]]

=== KE2x Suspension ===
=== KE3x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE5x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE7x Suspension ===
[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

User talk:Towe001

2011-03-04T04:37:37Z

Towe001: moved User talk:Towe001 to Talk:Tech:Engine/K Series/How to wire a 5k electronic distributor

#REDIRECT [[Talk:Tech:Engine/K Series/How to wire a 5k electronic distributor]]

Talk:Tech:Engine/K Series/Electronic distributor

2011-03-04T04:37:37Z

Towe001: moved User talk:Towe001 to Talk:Tech:Engine/K Series/How to wire a 5k electronic distributor

#REDIRECT [[Talk:Tech:Engine/K Series/Intake manifolds]]

User:Towe001

2011-03-04T04:37:37Z

Towe001: moved User:Towe001 to Tech:Engine/K Series/How to wire a 5k electronic distributor

#REDIRECT [[Tech:Engine/K Series/How to wire a 5k electronic distributor]]

Tech:Engine/K Series/Electronic distributor

2011-03-04T04:37:37Z

Towe001: moved User:Towe001 to Tech:Engine/K Series/How to wire a 5k electronic distributor

'''How to wire a 5k electronic distributor'''

The 5k distributor is a pulse generating type with inbuilt ignitor (ignition module). There is a two pin toyota connector with a black wire (negative) and a black with orange tracer (positive).

[[File:Sv108404.jpg|none|200px|caption]]

Remove your old points distributor, the 4mm black wire going to the distributor points is connected to the black wire on the two pin plug (this is negative switching for your coil). Connect the black with orange tracer to the positive side of your coil.

Note: if you have a ballast resistor on your coil you will need to change it to a 12v non resistor coil (I used a Gt40 coil), so disconnect the wire from the loom at the bottom of your ballast resistor and go straight to the + of your coil.

Write up - KE20rollabus
Edited by - towe001

http://www.rollaclub.com/board/topic/42941-how-to-wire-a-5k-electronic-distributor/#entry450206

Tech:Engine/K Series/Electronic distributor

2011-03-04T04:16:58Z

Towe001:

Main Page Old

2011-02-03T12:33:02Z

Towe001: Undo revision 3996 by Ermokyly (Talk)

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template1|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K Series/Intake manifolds|Intake manifolds]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

KE30/55
* [[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==
===General tips and hints===

* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

* [[Rear Leaf Springs]]

* [[Stud Pattern]]

=== KE1x Suspension ===

* [[Replacing front strut inserts on your KE1x]]

* [[Lowering KE1x Front using KE2x parts]]

* [[Suspension:KE1x Suspension/Tie Rods|Tie Rods]]

* [[Suspension:KE1x Suspension/Front Spring Upper Seats|Front Spring Upper Seats]]

=== KE2x Suspension ===
=== KE3x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE5x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE7x Suspension ===
[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

Main Page Old

2011-01-31T12:11:45Z

Towe001: Undo revision 3964 by Thomraed (Talk)

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template1|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K Series/Intake manifolds|Intake manifolds]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

KE30/55
* [[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==
===General tips and hints===

* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

* [[Rear Leaf Springs]]

* [[Stud Pattern]]

=== KE1x Suspension ===

* [[Replacing front strut inserts on your KE1x]]

* [[Lowering KE1x Front using KE2x parts]]

* [[Suspension:KE1x Suspension/Tie Rods|Tie Rods]]

* [[Suspension:KE1x Suspension/Front Spring Upper Seats|Front Spring Upper Seats]]

=== KE2x Suspension ===
=== KE3x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE5x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE7x Suspension ===
[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

Rear Leaf Springs

2011-01-12T13:06:16Z

Towe001:

'''Stiffness'''

The easiest way to change the stiff of the leaf pack is to remove leaves (softer rate) or add leaves (harder rate). You can usually add a leaf without changing the wrapping brackets, any more and you will have to make new wrappers. You can get custom leaves made up for about $15-$25 each.

Rob Dixon's tarmac rally setup is a custom leaf which matches the length of the 2nd-from-bottom leaf, except his custom leaf is 8mm thick, this is then placed on top of the leaf pack. Karl Skewes Jap-drift-spec setup was combining two KE35 leaf packs to make a 220lb 7-leaf pack.

'''Axle tramp'''

A common performance trick in the 70s when everything had leaves was to make thick metal brackets (like an = sign) and bolt the front of the pack together where each leaf ended.

Another method of reducing tramp is to add a thick leaf on top of the front section only of the leaf pack. I have read about people getting another top leaf (as in the one with the leaf eye), cutting the eye off, cutting the leaf off behind the U bolt, and attaching this above the original top leaf, to good effect.

If you're using old leaves, a cheap way of reducing tramp is simply to swap the leaves from side to side. After all the years of winding one way, reversing the winding will make the leaves stiffer temporarily. This may change back in a short amount of time, or it might take another 30-odd years :)

Beyond this, you can setup a trailing arm system, or 4-link/5-link , or a Kaltracks rear end, but these are all too complex to be within the scope of this article.

'''Lowering'''

There are a few ways of lowering leaf springs.

Firstly, you can use lowering blocks, where a block of steel is placed between the diff and leaf pack. The ride height of the car is lowered by the thickness of the block (ie: 30mm block, your car sits 30mm lower). This is pathetic American lazy-performance bullshit. Lowering blocks increase the torsional leverage on your leaf springs, which means you get increased axle tramp AND your leaves have greater force acting on them, so they bend out of shape quicker.

Another far better method is to invert the leaf eyes. The top leaves are heated until they become pliable, they eyes are unrolled and rolled back the other way, then heat treated again so the metal hardens properly. Most professional lowering kits you can buy are just an inverted-eye top leaf. This will give you a good couple of inches of drop.

Lastly, you can have your leaves reset. This de-arches the springs, which is alright to a point, you don't want your springs deforming past flat though.

'''Wagon Slapper Bar'''

Wagon leaf packs have a large bar on the bottom of the pack, not attached to anything. This is to stop your Corolla bottoming out when you're carrying around big heavy loads in the back (as you're able to with a wagon, not so much with a sedan). Jonny Rochester tried this slapper bar in a performance capacity when he had his KE38 wagon, but found the progression from soft stock leaves to hard slapper bar was too hard too fast.

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#Suspension Suspension]

Back to [http://www.rollaclub.com/wiki/index.php?title=Main_Page Main Page]

[http://www.rollaclub.com/ Rollaclub]

Main Page Old

2011-01-12T12:55:12Z

Towe001: /* Suspension */

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template1|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K Series/Intake manifolds|Intake manifolds]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

KE30/55
* [[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==
===General tips and hints===

* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

* [[Rear Leaf Springs]]

* [[Stud Pattern]]

=== KE1x Suspension ===

* [[Replacing front strut inserts on your KE1x]]

* [[Lowering KE1x Front using KE2x parts]]

* [[Suspension:KE1x Suspension/Tie Rods|Tie Rods]]

* [[Suspension:KE1x Suspension/Front Spring Upper Seats|Front Spring Upper Seats]]

=== KE2x Suspension ===
=== KE3x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE5x Suspension ===
[[KE55 Front Strut Upgrades]]
=== KE7x Suspension ===
[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

KE55 Front Strut Upgrades

2011-01-12T12:49:01Z

Towe001:

This is a quick Guide to What struts fit in the KE3X/ KE5X series corolla's.

'''XT130 Corona'''

XT130 Struts will NOT fit in as they are. You will need to cut the lower spring perch off and re welded KE30 or KE55 lower spring perch on. You will need to use the matching Top spring hat and the Top part with the studs. Coilovers would be the way to go though.

Other parts you will need is the XT130 steering arms, and the XT130 brake hoses.

'''TA22 Celica'''

TA22 will fit straight in as is with stock springs, and top hats ect.
Standard they are a tad higher, and also give a really small amount of + camber.
Ive found with 2.5" lowered springs the camber sits basically on 0. so longer LCA's or Camber tops will adjust this.

Other parts you will need is TA22 steering arms, also T18 steering arms fit as that's what im using, and also once again the Brake hose.

'''T-18'''

T-18 struts need the steering arms and brake hose from strut to caliper from the T-18 and the top hat (or bearing plate) from either the ke3x or '55 needs to be used.
On the series 1 T-18 ('79-'80?) the upper spring seat can be replaced with the upper spring seat from the ke3x/55 for an approx 1/4inch drop in height. I'm not sure about the series 2 T-18 springs.

'''RA40 Celica'''

Same deal as the XT130, needs spring perch re welded or convert to coil overs. and use the top hats from the KE30 or 55.

Parts needs is RA40 steering arms, and brake hoses.

'''KE70 Corolla'''

Close to being a bolt-in swap, only need the top hats (bearing plates) swapped over.
One good note for this is that the ke70 uses slimmer springs compared to the ke3x/55 so you'll the ability to camber the struts in more over what the stock '3x/55 struts can do.

Will be updating as i find out more about other struts, RA60 celica ones fit, but heard about + camber problems. but will update later

Falken_KE30 (aka Dan)

(T-18/KE70 info added - towe001)

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#Suspension Suspension]

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page Main Page]

Tech:Engine/K Series/80Amp Alternator Upgrade

2011-01-12T12:41:40Z

Towe001:

'''80Amp Alternator Upgrade'''

First off you need a vl 80amp alternator which looks like this
[[File:Alternator.jpg|none|200px]]
Make sure you get the loom connector that plugs into the regulator! Also grab a couple of regulators just in-case the ones in your vl alternator are worn!

'''Step 1''' - Dismantle the 4k alternator and vl alternators.
[[file:P1010792.JPG|left|200px]][[file:P1010793.JPG|center|200px]]
'''Step 2''' - swap all the internals from the vl alternator to the corolla casing and use the vl fan (more fins = better cooling)

'''Step 3''' - now remember those 4 LONG bolts holding the casing together? you need to find 2 about 2cm longer (i got mine from a 5k starter motor)

'''Step 4''' - install those 2 longer bolts with the rear bracket and bolt it all up

'''Step 5''' - install the regulator.

'''Step 6''' - there's 2 wires coming off the vl reg, a thick white wire and a small brown one. white is constant power and brown is for the battery light

i can't remember where they go into the corolla wiring but there's a small 2 pin plug going to the old alternator, one will have 12v constant and ignition power (use a multimeter)

'''Step 7''' - UPGRADE THE CHARGING WIRE! because that 2mm charging wire isn't gonna last long with 80 amps. now what i did was get a thick battery wire (from Supercheap) and wire it from alternator output post TO starter motor positive post. wires are hidden and looks neat

'''Step 8''' - install alternator and refit fan belt.

'''Step 9''' - start her up and turn all the lights on and check charging voltage

(i got 14.5v under full load with everything electrical cranking! my lights don't dim with my sub anymore :p)

it took me a GOOOD day to do all this. also paint the alternator housing/pulley/fan so they look shmick!

Taken from http://www.rollaclub.com/board/topic/44935-4k-80amp-alternator-upgrade/

----

''Article by Evan G / Towe001''

----

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#K_Series K Series]

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page Main Page]

[http://www.rollaclub.com/ Rollaclub]

Main Page Old

2010-12-27T14:30:54Z

Towe001: /* General Information */

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K Series/Intake manifolds|Intake manifolds]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==

[[Rear Leaf Springs]]

[[Stud Pattern]]

[[KE55 Front Strut Upgrades]]

=== KE1x Suspension ===

[[Replacing front strut inserts on your KE1x]]

[[Lowering KE1x Front using KE2x parts]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

== Suspension ==
* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

Talk:Tech:Engine/K Series/Electronic distributor

2010-12-27T14:30:40Z

Towe001: moved User talk:Towe001 to Talk:Tech:Engine/K Series/Intake manifolds

#REDIRECT [[Talk:Tech:Engine/K Series/Intake manifolds]]

Talk:Tech:Engine/K Series/Intake manifolds

2010-12-27T14:30:40Z

Towe001: moved User talk:Towe001 to Talk:Tech:Engine/K Series/Intake manifolds

Tech:Engine/K Series/Electronic distributor

2010-12-27T14:30:40Z

Towe001: moved User:Towe001 to Tech:Engine/K Series/Intake manifolds

#REDIRECT [[Tech:Engine/K Series/Intake manifolds]]

Tech:Engine/K Series/Intake manifolds

2010-12-27T14:30:40Z

Towe001: moved User:Towe001 to Tech:Engine/K Series/Intake manifolds

'''Intake manifolds for 3k / 4k'''

From what I know there are basically 4 different OME inlet manifolds for a 3/4 k that support single carby. Bigport (30mm) with bent runners. (Runners shrink in size in between head and plenum) Bigport (30mm) with straight runners. (Runners stay consistent in size and feed 2 to 1 then 2 to plenum) Mid port (27mm) with bent runners. (Runners stay consistent in size and feed 4 to 1) Small port (25mm) with bents runners. (stock) The bigport with straight runner has other issues, It's plenum area is small you could hog this out, and it does not support a dual exhaust manifold so any HP gains in the inlet will be lost in the exhaust, you could get around the exhaust issue with extractors.

Here's some pix to tell the story.

Common small port as we all know and love.
[[File:Small_port.jpg|none|200px|caption]]

Midport I suspect these are on 4k and later but now sure.
[[File:Mid_port_bent.jpg|none|200px|caption]]

Common bigport.
[[File:Bigport_bent.jpg|none|200px|caption]]

Early biport I think.
[[File:Biportstraight.jpg|none|200px|caption]]

Bigport straight plenum area.
[[File:Bigportstraightplenem.jpg|none|200px|caption]]

Bigport straight runner sizes.
[[File:Bigportstraightdowntherunner.jpg|none|200px|caption]]

Bigport straight note exhaust triangle is 180 deg out.
[[File:Bigport_diff_in_exhaust.jpg|none|200px|caption]]

Bigport straight exhaust manafold.
[[File:Bigportstraightexhaust.jpg|none|200px|caption]]

Taken from http://www.rollaclub.com/board/topic/44925-bigport-manifolds-for-3k/page__view__findpost__p__468972

----

''Article by Andy43 / Towe001''

----

Back to [http://www.rollaclub.com/faq/index.php?title=Main_Page#K_Series K Series]

Back to [http://www.rollaclub.com/wiki/index.php?title=Main_Page Main Page]

[http://www.rollaclub.com/ Rollaclub]

Tech:Engine/K Series/Intake manifolds

2010-12-27T14:28:49Z

Towe001:

File:Bigportstraightexhaust.jpg

2010-12-27T14:13:28Z

Towe001:

File:Bigport diff in exhaust.jpg

2010-12-27T14:12:24Z

Towe001:

File:Bigportstraightdowntherunner.jpg

2010-12-27T14:11:53Z

Towe001:

File:Bigportstraightplenem.jpg

2010-12-27T14:10:37Z

Towe001:

File:Biportstraight.jpg

2010-12-27T14:09:31Z

Towe001:

File:Bigport bent.jpg

2010-12-27T14:08:16Z

Towe001:

File:Mid port bent.jpg

2010-12-27T14:05:58Z

Towe001:

File:Small port.jpg

2010-12-27T14:00:22Z

Towe001:

Tech:Engine/K Series/Intake manifolds

2010-12-13T13:43:55Z

Towe001:

#REDIRECT

Talk:Tech:Engine/K Series/Intake manifolds

2010-12-13T13:34:07Z

Towe001: Blanked the page

Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

2010-12-13T13:28:15Z

Towe001:

'''Ke55 Round Headlight Conversion'''

Fairly straight forward in the conversion.
About the only parts needed are
* Headlight buckets
* Adjusting springs
* Adjusting screws
* Chrome surrounds
* Grill

Tools
* Phillips screw driver
* Needle nose pliers
* Hacksaw blade or something similar to cut the brackets

Yellow circles are the brackets that need to be removed, red circles are where the adjusting screws go into (new clip things and the screws, you should be able to get from an auto shop), the blue circles is what the spring goes onto.
[[File:Corollafront30sj.jpg|center|200px]]
''Note''

If you use KE55 round headlights, use a KE55 round headlight grill, and if you use KE35 round headlights, use the KE35 grille. The cups that the lights sit in are different, and if you mix and match the grilles the lights look funny (sit too far in or out).

http://www.rollaclub.com/board/topic/5958-ke55-round-headlightfront-end-conversion/

Edited by towe001

Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

2010-12-13T13:27:50Z

Towe001:

Ke55 Round Headlight Conversion

Fairly straight forward in the conversion.
About the only parts needed are
* Headlight buckets
* Adjusting springs
* Adjusting screws
* Chrome surrounds
* Grill

Tools
* Phillips screw driver
* Needle nose pliers
* Hacksaw blade or something similar to cut the brackets

Yellow circles are the brackets that need to be removed, red circles are where the adjusting screws go into (new clip things and the screws, you should be able to get from an auto shop), the blue circles is what the spring goes onto.
[[File:Corollafront30sj.jpg|center|200px]]
''Note''

If you use KE55 round headlights, use a KE55 round headlight grill, and if you use KE35 round headlights, use the KE35 grille. The cups that the lights sit in are different, and if you mix and match the grilles the lights look funny (sit too far in or out).

http://www.rollaclub.com/board/topic/5958-ke55-round-headlightfront-end-conversion/

Edited by towe001

Main Page Old

2010-12-07T10:06:22Z

Towe001: /* KE50/55 */

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion|Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==

[[Rear Leaf Springs]]

[[Stud Pattern]]

[[KE55 Front Strut Upgrades]]

=== KE1x Suspension ===

[[Replacing front strut inserts on your KE1x]]

[[Lowering KE1x Front using KE2x parts]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

== Suspension ==
* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

Talk:Tech:Engine/K Series/Intake manifolds

2010-12-05T12:02:25Z

Towe001: moved User talk:Towe001 to Talk:Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

#REDIRECT [[Talk:Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion]]

Talk:Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

2010-12-05T12:02:25Z

Towe001: moved User talk:Towe001 to Talk:Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

#REDIRECT [[Tech:Engine/K Series/80Amp Alternator Upgrade]]

Tech:Engine/K Series/Intake manifolds

2010-12-05T12:02:25Z

Towe001: moved User:Towe001 to Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

#REDIRECT [[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion]]

Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

2010-12-05T12:02:25Z

Towe001: moved User:Towe001 to Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

Main Page Old

2010-12-05T11:59:04Z

Towe001: /* KE50/55 */

'''Welcome to the Rollaclub FAQ'''

This FAQ Has been migrated to WIKI format from the Oldcorollas FAQ, maintained by Super Jamie.

Further Discussion of any articles here may be made on the:
[http://groups.yahoo.com/group/oldcorollas/ Old Corollas Yahoo Group]
andhttp://www.rollaclub.com/faq/index.php?title=Main_Page
[http://www.rollaclub.com/board/ Rollaclub Messageboard]

=Series=

==K==

===Model===

====KE10/11/15/16/17/18====

*[[Series:K/Model/KE10/11/15/16/17/18/Template|Template]]

====KE20/25====

*[[Series:K/Model/KE20/25/Template|Template]]

====KE30/35/36/38====

*[[Series:K/Model/KE30/35/36/38/Template|Template]]

====KE50/55====

*[[Series:K/Model/KE50/KE55/Template|Template]]
*[[Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion]]

====KE70====

*[[Series:K/Model/AE70/71/85/86/Template|Panel Interchanability]]
*[[Series:K/Model/AE70/71/85/86/Template|Brakes]]
*[[Series:K/Model/AE70/71/85/86/Template|Suspension]]

==A==

===Model===

====AE70/71/85/86====

*[[Series:A/Model/AE70/71/85/86/Template|Template]]

*[[Series:A/Model/AE70/71/85/86/RWD 4age Part Numbers|RWD 4age Part Numbers]]

*[[Series:A/Model/AE70/71/85/86/Installing An Electronic Distributor|Installing An Electronic Distributor]]

====AE80/82====

*[[Series:A/Model/AE80/82/AE80/82 Body Panels|AE80/82 Body Panels]]

*[[Series:A/Model/AE80/82/4age Diagnostic System|AE82 4age Diagnostic System]]

*[[Series:A/Model/AE80/82/Converting To Twincam|Converting To Twincam]]

*[[Series:A/Model/AE80/82/How To Identify A Series 3 Twincam|How To Identify A Series 3 Twincam]]

*[[Series:A/Model/AE80/82/Making A Fuel Pump Access Panel|Making A Fuel Pump Access Panel]]

*[[Series:A/Model/AE80/82/Removed The Aircon And The Thermo Now Runs?|Removed The Aircon And The Thermo Now Runs?]]

====AE90/92/93/94/95====

*[[Series:A/Model/AE90/92/93/94/95Template|Template]]

= Tech =

== Engine ==

=== K Series ===

==== General Information ====

[[Tech:Engine/K Series/Alternator|Alternator]]

*[[Tech:Engine/K Series/80Amp Alternator Upgrade|80Amp Alternator Upgrade]]

[[Tech:Engine/K Series/Blocks|Blocks]]

[[Tech:Engine/K Series/Camshaft|Camshaft]]

[[Tech:Engine/K_Series/Carburettor|Carburettor]]

[[Tech:Engine/K Series/Heads|Cylinder Heads]]

[[Tech:Engine/K_Series/Distributor|Distributor]]

[[Tech:Engine/K_Series/EFI|Electronic Fuel Injection]]

[[Tech:Engine/K Series/Emissions System|Emissions System]]

[[Tech:Engine/K_Series/Exhaust|Exhaust]]

[[Tech:Engine/K Series/Flywheel|Flywheel]]

[[Tech:Engine/K_Series/Fuel Filter|Fuel Filter]]

[[Tech:Engine/K_Series/Fuel Pump|Fuel Pump]]

[[Tech:Engine/K_Series/Gearboxes|Gearboxes]]

[[Tech:Engine/K_Series/How_to_build_a_tough_K_motor|How To Build A Tough 'K' Motor]]

[[Tech:Engine/K_Series/Boosted K motors|Boosted K motors]]

[[Tech:Engine/K Series/How To Fix K Motor Oil Leaks (Problems And Cures)|How To Fix 'K' Motor Oil Leaks (Problems And Cures)]]

[[Tech:Engine/K_Series/K|KE1x Series 'K' Engine Specific Info]]

[[Tech:Engine/Mounts|Mounts]]

[[Tech:Engine/K_Series/Distrib|Nippon Denso Distributor Part Numbers]]

[[Oil Pump]]

[[Tech:Engine/K_Series/Part Numbers|Part Numbers]]

[[Tech:Engine/K_Series/Starter Motor|Starter Motor]]

[[Sump]]

[[Tech:Engine/K Series/Torque_Settings|Torque Settings]]

[[Tech:Engine/K_Series/Valve Clearances|Valve Clearances]]

[[Tech:Engine/K-Series/TRD Uprite Kit|TRD Upright Kit]]

[[Tech:Engine/K-Series/TRD|How to build a TRD spec Upright motor!]]

[[Tech:Engine/K_Series/4kstall|What Is A Fuel Solenoid?]]

==== K (1077cc) ====

==== 2K (993cc) ====

==== 3K (1166cc) ====

[[Tech:Engine/K_Series/3K-B/Bigport Head|Bigport Head]]

[[Tech:Engine/K_Series/3K-B/Factory Twin Carbs|Factory Twin Carbs]]

==== 4K (1290cc) ====

'''------------4K-C'''

[[Tech:Engine/K_Series/4K-C/4K-C Emission System Diagram|4K-C Emission System Diagram]]

'''------------4K-E'''

[[Tech:Engine/K_Series/4K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/4K-E/Injectors|Injectors]]

[[Tech:Engine/K_Series/4K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/4K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/4K-E/Rocker Cover|Rocker Cover]]

==== 5K (1496cc) ====

[[Tech:Engine/K_Series/5K-C/5K Hydraulic To Solid Lifter Conversion|5K Hydraulic To Solid Lifter Conversion]]

==== 7K (1812cc) ====

[[Tech:Engine/K_Series/7K-E/Distributor|Distributor]]

[[Tech:Engine/K_Series/7K-E/Intake Manifold|Intake Manifold]]

[[Tech:Engine/K_Series/7K-E/Pinouts|Pinouts]]

[[Tech:Engine/K_Series/7K-E/Terminal Voltages And Diagnostic Codes|Terminal Voltages And Diagnostic Codes]]

=== A Series ===

[[Tech:Engine/A Series/A-Series Engine FAQ|A-Series Engine FAQ]]

[[Tech:Engine/A Series/Alternator Wiring Diagram|Alternator Wiring Diagram]]

[[Tech:Engine/A Series/Blocks|Blocks]]

[[Tech:Engine/A Series/Converting to RWD|Converting to RWD]]

[[Tech:Engine/A Series/Cooling Guide|Cooling Guide]]

[[Tech:Engine/A Series/Crossmembers|Crossmembers]]

[[Tech:Engine/A Series/ECU Pinouts|ECU Pinouts]]

[[Tech:Engine/A Series/External Thermostat|External Thermostat]]

[[Tech:Engine/A Series/Gearboxes|Gearboxes]]

[[Tech:Engine/A Series/Heads|Heads]]

[[Tech:Engine/A Series/Injectors|Injectors]]

[[Tech:Engine/A Series/Installing EFI Lifter Pump into AE86 Fuel Tank|Installing EFI Lifter Pump into AE86 Fuel Tank]]

[[Tech:Engine/A Series/Internals|Internals]]

[[Tech:Engine/A Series/Part Numbers|Part Numbers]]

[[Tech:Engine/A Series/Rear Water Outlet|Rear Water Outlet]]

[[Tech:Engine/A Series/Rebuilding Your 4ag(z)e|Rebuilding Your 4AG(Z)E]]

[[Tech:Engine/A Series/Replacing Your Timing Belt|Replacing Your Timing Belt]]

[[Tech:Engine/A Series/TVIS|What Is TVIS?]]

[[Tech:Engine/A Series/Wiring Diagrams|Wiring Diagrams]]

[[Removing the Air Bypass Valve on a 4agze]]

=== S Series ===

[[Tech:Engine/S Series/Blocks|Blocks]]

[[Tech:Engine/S Series/Head|Head]]

[[Tech:Engine/S Series/EFI|EFI]]

[[Tech:Engine/S Series/Converting to RWD|Converting to RWD]]

=== T Series ===

[[Tech:Engine/T Series/Blocks|Blocks]]

[[Tech:Engine/T Series/Gearboxes|Gearboxes]]

=== E Series ===
[[Tech:Engine/E Series/Blocks|Blocks]]

== [[:Category:Fuel System | Fuel System]] ==

[[EFI]]

[[Fuel]]

[[How To Set Up Your Fuel System]]

== [[:Category: Drivetrain | Drivetrain]] ==

(In logical order of drivetrain after the flywheel)

[[Tech:Drivetrain/Bellhousing|Bellhousing]]

[[Clutch]]

[[Automatic Gearbox]]

[[Manual Gearbox]]

* [[Removing Spigot Bearings]]

[[Tailshaft]]

[[Differential Gears]]

[[Differential Housing]]

[[Axles]]

--[[User:Grimwolge|Grimwolge]] 12:46, 18 Jul 2005 (EST)

== Suspension ==

[[Rear Leaf Springs]]

[[Stud Pattern]]

[[KE55 Front Strut Upgrades]]

=== KE1x Suspension ===

[[Replacing front strut inserts on your KE1x]]

[[Lowering KE1x Front using KE2x parts]]

== Brakes ==

[[Front Disc Brakes]]

[[Rear Disc Brakes]]

== Electrical ==

[[Alternator]]

[[Dash Cluster]]

[[Distributor]]

[[Headlights]]

[[Relays]]

[[Starter Motor]]

[[Spark Plug Types]]

[[Tachometer]]

[[Thermo Fan]]

[[Wiring Diagrams]]

== Emission Systems ==

[[Emission System Abbreviations|Emission System Abbreviations]]

[[Emission System Components|Emission System Components]]

== Reference Material ==

[[Corolla Model Numbers]]

[[Homologations]] - Listing of FIA Homologated Corollas for Group 1-4 and Group A

[[Books]]

Codes - Engine, Body, Axle

Service

Torque Specs

* [[Reference:What Carb| What Carb is that ?]]

* [http://www.rollaclub.com/hosted/AE86Manual.pdf.gz AE86 Manual]

* [http://www.rollaclub.com/hosted/KE70_Chassis_Electrical_System.pdf KE70 Chassis Electrical System]

* [http://www.rollaclub.com/hosted/Starlet_Manual_Supplement_&_Revisions.zip KP61 Starlet Manual includes 4KE EFI]

* [http://home.onthenet.com.au/~paulp/Blacktop/ Blacktop 4AGE Manual]

= Maintenance =

== Body ==
* [[Maintenance:Body/Fixing Rust| Fixing Rust]]

== Engine ==
* [[Maintenance:Engine/Decarbonising| Decarbonising an engine]]

== Suspension ==
* [[Maintenance:Suspension/Control Arm Bushes| Control Arm Bushes]]

= Upgrades =
[[Upgrades:Ke55 boot release|Ke55 Boot Release]]

[[Upgrades:Corona Power Mirrors into late KE70/AE71| Corona Power Mirrors into late KE70/AE71]]

[[Upgrades:Hilux Diff Conversion| Hilux Diff Conversion Into KE55]]

[[Upgrades:KE70 cable to hydraulic clutch|KE70 cable to hydraulic clutch]]

[[Upgrades:KE70 K50 gearbox into 3K powered KE20| KE70 K50 into 3K powered KE20]]

[[Upgrades:KE70 Single to Twin Headlight Wiring|KE70 Single to Twin Headlight Wiring]]

[[Upgrades:Nikki Carb onto K motor|Nikki carb onto K motor]]

[[Upgrades:Sigma Control Arms| Sigma Control Arms]]

== Engineering your Car ==

===[[Overview]]===

[[South Australia]]

[[Victoria]]

= History =
[[History:60s |The '60s]]

[[History:70s |The '70s]]

[[History:80s |The '80s]]

[[History:90s |The '90s]]

[[History:Racing | Racing]]

RWD corolla history
http://reocities.com/COLOSSEUM/4883/crwd.html

= Related =
[[Car Movies]]

----
the bit where jamie can edit the main page is cool :D

Series:K/Model/KE50/KE55/Ke55 Round Headlight Conversion

2010-12-05T11:56:39Z

Towe001: Created page with ''''Ke55 Round Headlight Conversion''' Fairly straight forward in the conversion. About the only parts needed are * Headlight buckets * Adjusting springs * Adjusting screws * Chr…'